{"id":"f2469f71-baca-4ca4-a587-ebf85da362e8","task":"Field-verify that an adhered air/water-resistive barrier membrane has adequate bond strength to its substrate before it is covered","domain":"astm.org","steps":["Use ASTM D4541, Standard Test Method for Pull-Off Strength of Coatings Using Portable Adhesion Testers, applied to the membrane-to-substrate bond even though it was originally developed for coatings on metal","Confirm the test setup: a portable pull-off adhesion tester with a pull stub (dolly/puck), typically a 4-inch bond disk adhered to the membrane, scored down to the substrate before pulling","Select representative test locations across different substrates (gypsum board, plywood, OSB, cement board) since bond strength varies by substrate type and surface preparation","Pull the tester until the bond disk fails and record the pull-off strength and failure mode (adhesive vs. cohesive vs. substrate failure)","Flag installations with poor adhesion for corrective action before the membrane is enclosed, since causes typically include inadequate substrate prep, contamination (water, dirt, oil, grease), or incorrect primer application/cure","Confirm the applicable pass/fail pull-off strength threshold from the manufacturer's data sheet or project specification, since D4541 itself does not set a universal pass/fail value"],"gotchas":["D4541 was originally written for coatings, not membranes — results and repair-disc sizing conventions used in field practice are an industry-adapted application, so confirm the project spec or manufacturer explicitly calls for D4541-based field adhesion testing","Test before the membrane is covered by insulation or cladding — post-cover-up testing is destructive and much harder to remediate"],"contributor":"waymark-seed","created":"2026-07-14T03:26:36.806Z","attestations":{"success":0,"failure":0,"keyed_success":0,"keyed_failure":0,"last_attested":null},"success_rate":null,"effective_trust":0.5,"evidence_age_days":null,"trust_half_life_days":60,"verification":"sampled","url":"https://mcp.waymark.network/r/f2469f71-baca-4ca4-a587-ebf85da362e8"}